Clik here to view.
Radiator fan repair bearing
Summer arrived and A/C is heavily used. After stopping the engine noticed loud banging from engine bay. It took me an hour or so to track down that sound. Sound only occurs when A/C is on. First...
View ArticleClik here to view.
Wiring harness
image.jpg (Size: 1.3 MB / Downloads: 26) Afternoon all. Took the floor out my 2006 Berlingo van. On the drivers side there is 3 plugs 2 go into the seat and I can't remember for the life of me where...
View ArticleClik here to view.
Bleed screw for coolant on Berlingo 1.9D (DW8B engine)?
Hi folks, I found this great forum through the 1.9d coolant change thread but it doesn't really have a solution. I've also read this Coolant renewal thread. I am trying to drain all coolant out of my...
View ArticleClik here to view.
Drivers rear door window smashed
My drivers rear door window has smashed and not sure of my options. I've managed to remove most of the bonding but can't seem to find a replacement. Was thinking of getting a plastic one cut but not...
View ArticleKnocking
I have recently noticed a knocking mainly when I turn the engine off or if I am turning in reverse. Anyone had this problem before? If so what could it be? Thanks
View Article1.9d, even slower than usual..
Hiya All... Has anyone noticed that their 1.9d is slower than usual ? It might be just mine but I have noticed that sometimes it goes as expected and sometimes it barely has enough power to rev...
View ArticleAdvice for replacing anti roll linkage??
Right folks, my car is going in for an MOT on Saturday and I know that my anti roll bar linkage needs replaced. The knocking is driving me nuts and when it was in getting new tyres they warned me that...
View ArticleRadiator removal
Hi, I need to replace the radiator on my 2006 Berlingo 1.4 petrol. I've read many of the very useful threads but still have a couple of questions. I can see that I need to release the 3 main hoses by...
View Articlesudden knocking
hi was driving today then i noticed the engine knocking and running rough ,managed to limp home ,tried starting it up just now still knocking lumpy and smokey any advice will hep thanks ,08 plate 1.6...
View ArticlePassenger Seat Storage Tray Removal?
Hi all, Just wondering how do you remove the Passenger Seat Storage Tray. Just looking at this to hide away a small amp to run a subwoofer. Thanks
View ArticleIntermiitent misfire with accompanying smoke
My 2005 1.9 diesel Berlingo van has me baffled. It has a misfire that develops over time where it feels like it's running on 3 cylinders when under load. If I ease off the pedal then it runs much...
View ArticleRear brake issues
Long story short, i put on a new refurbished axle, new flexis and all new copper brake lines. Only thing not changed was the brake compensator valve. I did put on a new spring (ebay) and set that just...
View ArticleEngine runs hot
Hi, I have a Peugeot Partner 2003 1.9d. I have observed that over a while, the low speed fan kicks in at an ever increasing temperature. Currently it kicks in at 98-99 degrees whereas when I got it 7...
View ArticleDriveshaft noise
The cars started making a clicking clunky noise when I pull away and brake at low speed. It sounds like a dodgy bearing. Has anyone any ideas what it could be?
View ArticleRocker cover oil leak
I have a look around the rocker cover and looks like below that too which I believe is a sealed rather than a runner gasket. My question is, do I have to remove the timing belt cover to gain access to...
View ArticleTiming Belt Replacement issue
Hi all, looking for a bit of advice and Im hoping someone can help before I go bald. Have had to replace timing belt on 1.6hdi 2008 berlingo van due to water pump failure, also rough running and think...
View Articlegot a few probs advice needed
hello all just bought a 55 plate partner 2.0 hdi combi, im happy with it but got a few probs i want to sort so any advice helpfull thanks, steering is losing its assitance on 1/4 lock steering wheel is...
View ArticleStiff accelerator pedal
Forgive me if this has been answered before but I can't find the answer? The accelorator pedal feels really stif.. I have a 04 plate 19 D van. I followed the cable and sprayed WD40 all over it and...
View ArticleClik here to view.
Gauges turning off randomly
Hoping someone can help with this. Every once in a while (twice last week and again today) my gauges just stop reading and all the warning lights come on (see photo). The van drives absolutely fine....
View ArticleRear Fog light and reversing lights question
I have just bought a 04 plate 1.9d Berlingo van and have a few issues and Questions ? 1/ How many rear fog light should I have ? I have got one on the drivers side 2/ How many reversing lights should I...
View Article