Clik here to view.
1.6HDI 75 bigger turbo (from 90, 1xx)?
A friend of mine who is a mechanic had to replace the engine in a Peugeot 3008 last week, he used the engine out of a Berlingo M59 if I'm not mistaken. Both 1.6HDI, but I don't now the hp figures. On...
View ArticleTAILGATE LOCKING PROBLEM
Hi all,i have looked through threads for my problem, but did not find what i was looking for.My tailgate is not locking with fob or with the key ??? when i finally lock it (after quite a few minutes) I...
View ArticleDiesel fan in Petrol engine?
Hi there, I have a 2003, Berlingo Multispace and the radiator fan doesn't work. I bought a new one to have fitted but the mechanic who was working on it said that it actually has a fan for a diesel and...
View ArticleClik here to view.
Electrical Fault
Have message Front drivers door open .. On Dash computer scrolling across . and also had problems with central locking. any ideas more than welcome .. also speedo stops working for a while and then...
View ArticleD.M.F.
Hi. My dear old Berlingo 2.0ltr HDI has a judder when idling. Been told this is due to a worn Dual Mass Flywheel by one garage and 'Could be an engine mount' by another. Does the 2.0 ltr Diesel have a...
View ArticleFront camber out of alignment after wheel size change
Hi folks, Since I swapped my M59 14 Inch steels (175/70/14) for 15 Inch 205gti speedlines (195/60/15), the front camber went out of alignment and after I took it to the best alignment shop, they let...
View ArticleCruise control possible or not, how to check?
So I'm considering adding cruise control to my '06 M59 1.6HDI (9HV DV6BTED4) I talked to the local dealership and it would cost me €9x for the stalk and €25 for coding, very reasonable if you ask me....
View Article1.9 dw8 to b 1.8 xud engine swap
Hi, I bought a real clean 2003 1.9 berlingo but it had a stuffed engine. I have a rotten mk1 berlingo but it has a real good engine so the plan was to swap the dw8 with the xud. All went to plan until...
View ArticleClik here to view.
Window mechanism replacement.. ebay unit seems different
The mechanism in my drivers door decided to mangle itself, so I bought a replacement from ebay. The new one came with no motor, so I just needed to swap the motor from the old one. simple? er, no....
View ArticleDead BSI unit?
I'm trying to repair a 2003 hdi. When the battery is connected, the headlights come on. There's no diesel heater light and the engine won't start. Also the hazards/indicators/wipers/radio controls...
View ArticleRemoving Fuel tank/ sender unit faulty ??
Anyone here ever had a problem with the sender unit located in the fuel tank ? I think it may be whats causing the fault with my van, Its alternating between surging and loosing power but only happens...
View Article2004 2.0HDi Cruise Control - Lexia or Diagbox?
Sorry for yet another CC thread, I've read most, if not all of them here and on other forums and I'm about to try & fit CC to my '04 2.0 This is my first 'modern' Citroen, and my first look at...
View ArticleRadio not working and electrics
hi all im new to this forum, I bought a 04 plate berlingo 1.9D and ive had a few problems with it. The first is the radio doesn't work - no power nothing all the fuses seem ok ive had it out and the...
View ArticleAnother engine swap thread
Hi all, Currently running a DW8 dog. SO....I've sourced a professionally built 1.4 TU engine from a 106 that is putting out 132 bhp. It has stand alone management, comes with pressure regulator &...
View ArticleClik here to view.
Rear axle refurbished recommendations ?
Rear right hand Torsion bar snapped while driving yesterday. Made a very satisfying noise and put the shits right up the wife . I was driving and pretty much knew what was going on so no panic....
View ArticleGears / Clutch problems
Hi I have a 2007 Diesel Multispace. For a little while not the clutch has been slipping, but only slightly, and only every now and then. We asked our local garage if the clutch needed to be replaced...
View ArticleClik here to view.
squealing/grinding reverse only?
I fitted a new clutch kit and after around 30 miles with no problems I have now noticed a squealing/grinding noise in reverse only. It sounds like metal on metal I have been told its my release bearing...
View ArticleLexia clone that works with 2003 model?
Ongoing non-start 'fun' with a 2003 Berlingo Multispace 1.9D !! Having decided that the only hope is to purchase a Lexia, I'm having a massive problem with finding one of the clones that will work with...
View Articleslow to finish reading data on dashboard
sorry.. hard to give this a title! 2.0 hdi 2004/5 blingo. i was told when i first bought my blingo to wait for dashboard readout to show mileage, i.e. after oil level is show. mine takes between 30...
View ArticleEngine warning light
Hi guys, here's the problem... Engine warning light is on but my odbii code reader says there are no faults. Is it a crappy code reader or a dodgy dash light? Any clues? Sent from my VF-1397 using...
View Article